SEMICONDUCTOR MATERIALS

Structural, optical, morphological and electrical properties of undoped and Al-doped ZnO thin films prepared using sol-gel dip coating process

N. Boukhenoufa1, R. Mahamdi1 and D. Rechem2

+ Author Affiliations

 Corresponding author: N.Boukhenoufa, boukhenoufanour@gmail.com;faycaldzdz@hotmail.com

PDF

Abstract: In this work, sol-gel dip-coating technique was used to elaborate ZnO pure and ZnO/Al films. The impact of Al-doped concentration on the structural, optical, surface morphological and electrical properties of the elaborated samples was investigated. It was found that better electrical and optical performances have been obtained for an Al concentration equal to 5%, where the ZnO thin films exhibit a resistivity value equal to 1.64104 Ω·cm. Moreover, highest transparency has been recorded for the same Al concentration value. The obtained results from this investigation make the developed thin film structure a potential candidate for high optoelectronic performance applications.

Key words: sol-gel dip-coatingdoped ZnOoptoelectronictransmittanceRMSresistivity



[1]
Aydemir S, Karakaya S. Effects of withdrawal speed on the structural and optical properties of sol-gel derived ZnO thin films. J Magn Magn Mater, 2015, 373:33 doi: 10.1016/j.jmmm.2014.01.077
[2]
Sun Guipeng, Yan Jinliang, Niu Peijiang, et al. Electronic structure and optical property of p-type Zn-doped SnO2 with Sn vacancy. Journal of Semiconductors 2016, 37(2):023005 doi: 10.1088/1674-4926/37/2/023005
[3]
Ozgur U, Alivov Y I, Liu C, et al. A comprehensive review of ZnO materials and devices. J Appl Phys, 2005, 98(4):041301 doi: 10.1063/1.1992666
[4]
Shewale P S, Yu Y S. Growth-temperature-dependent optical and acetone detection properties of ZnO thin films. Journal of Semiconductors, 2015, 36(7):073001 doi: 10.1088/1674-4926/36/7/073001
[5]
Benhaliliba M, Tiburcio-Silver A, Avila-Garcia A, et al. The sprayed ZnO films:nanostructures and physical parameters. Journal of Semiconductors, 2015, 36(8):083001 doi: 10.1088/1674-4926/36/8/083001
[6]
Suvaci E, Özer İ Ö. Processing of textured zinc oxide varistors via templated grain growth. J Eur Ceram Soc, 2005, 25:1663 doi: 10.1016/j.jeurceramsoc.2004.05.026
[7]
Liang S, Sheng H, Liu Y, et al. ZnO Schottky ultraviolet photodetectors. J Cryst Growth, 2001, 225:110 doi: 10.1016/S0022-0248(01)00830-2
[8]
Pan Z, Tian X, Hu J, et al. Investigation of optical and electronic properties in Al-Sn co-doped ZnO thin films. Mater Sci Semicond Process, 2013, 16:587 doi: 10.1016/j.mssp.2012.06.020
[9]
Qu X, Lu S, Jia D, et al. First-principles study of the electronic structure of Al and Sn co-doping ZnO system. Mater Sci Semicond Process, 2013, 16:1057 doi: 10.1016/j.mssp.2013.04.002
[10]
Tian X, Pan Z, Zhang H, et al. Growth and characterization of the Al-doped and Al-Sn co-doped ZnO nanostructures. Ceram Int, 2013, 39:6497 doi: 10.1016/j.ceramint.2013.01.081
[11]
Huang M C, Wang T H, Cheng S H, et al. The structure and photoelectrochemistry of Al, Ti co-doped zinc oxide thin films prepared by sol-gel dip-coating process. Nanosci Nanotechnol Lett, 2014, 6:210 doi: 10.1166/nnl.2014.1754
[12]
Oleynik N, Adam M, Krtschil A. MOVPE growth and characterization of ZnO properties for optoelectronic applications. J Cryst Growth, 2003, 248:14 doi: 10.1016/S0022-0248(02)01879-1
[13]
Caglar Y, Caglar M, Ilikan S. Microstructural, optical and electrical studies on sol-gel derived ZnO and ZnO:Al films. Curr Appl Phys, 2012, 12(8):963 http://cn.bing.com/academic/profile?id=2006989597&encoded=0&v=paper_preview&mkt=zh-cn
[14]
Xu Z Q, Deng H, Li Y, et al. Ultraviolet photoconductive detector based on Al doped ZnO films prepared by sol-gel method. Appl Surf Sci, 2006, 253:476 doi: 10.1016/j.apsusc.2005.12.113
[15]
Kuo S Y, Chen W C, Lai F I. et al. Effects of doping concentration and annealing temperature on properties of highly-oriented Aldoped ZnO films. J Cryst Growth, 2006, 287(1):78 doi: 10.1016/j.jcrysgro.2005.10.047
[16]
Benouis C E, Benhaliliba M, Juareze A S, et al. The effect of indium doping on structural, electrical conductivity, photoconductivity and density of states properties of ZnO films. Journal of Alloys and Compounds, 2010, 490:62 doi: 10.1016/j.jallcom.2009.10.098
[17]
Hsu L S, Yeh C S, Kuo C C, et al. Optical and transport properties of undoped and Al-, Ga-and In-doped ZnO thin films. J Optoelectron Adv Mater, 2005, 7(6):3039 http://joam.inoe.ro/arhiva/pdf7_6/Hsu.pdf
[18]
Caglar Y, Ilican S, Caglar M, et al. Effects of In, Al and Sn dopants on the structural and optical properties of ZnO thin films. Spectrochim Acta, 2007, 67:1113 doi: 10.1016/j.saa.2006.09.035
[19]
Lucio-Lopez M A, Luna-Arias M A, Maldonado A, et al. Doublelayer indium doped zinc oxide for silicon thin-film solar cell prepared by ultrasonic spray pyrolysis. Solar Energy Mater Solar Cells, 2006, 90:733 doi: 10.1016/j.solmat.2005.04.010
[20]
Ratheesh Kumar P M, SudhaKartha C, Vijayakumar K P. Doping of spray-pyrolyzed ZnO thin films through direct diffusion of indium:structural optical and electrical studies. J Appl Phys, 2012, 98:023509 http://cn.bing.com/academic/profile?id=2086104209&encoded=0&v=paper_preview&mkt=zh-cn
[21]
Xue S W, Zu X T, Zhou W L, et al. Effects of post-thermal annealing on the optical constants of ZnO thin film. Journal of Alloys and Compounds, 2008, 448:21 doi: 10.1016/j.jallcom.2006.10.076
[22]
Ghosh R, Paul G K, Basak D. Structural and optical characterization of high-quality ZnO. Materials Research Bulletin, 2005, 40:190
[23]
Arif A, Belahssen O, Gareh S, et al. Influence of precursor molarity on the optical properties of ZnO thin films. Journal of Semiconductors, 2015, 36(1):013001 doi: 10.1088/1674-4926/36/1/013001
[24]
Mahmood K, Amin N, Ali A, et al. Enhancement of phosphorssolubility in ZnO by thermal annealing. Journal of Semiconductors, 2015, 36(12):123001 doi: 10.1088/1674-4926/36/12/123001
[25]
Ghosh D S, Chena T L, Formica N, et al. High figure-of-merit Ag/Al:ZnO nano-thick transparent electrodes for indium-free flexible photovoltaics. Solar Energy Materials and Solar Cells, 2012, 107:338 doi: 10.1016/j.solmat.2012.07.009
[26]
Zhanchang P, Xinlong T, Guanghui H, et al. Investigation of optical and electronic properties in Al-Sn co-doped ZnO thin films. Materials Science in Semiconductor Processing, 2013, 587:592 http://cn.bing.com/academic/profile?id=2083150510&encoded=0&v=paper_preview&mkt=zh-cn
Fig. 1.  Diagram of the procedure for preparing Al-doped ZnO thin films.

Fig. 2.  Diffraction spectrum XRD of ZnO thin films undoped and doped with Al (0\% -3\% -5\% -10\%)

Fig. 3.  Transmittance spectra of ZnO thin films for different Al concentration.

Fig. 4.  Eg variation versus the Al-doping concentration.

Fig. 5.  (a) AFM microscopy apparatus used in the surface morphology characterization. (b) Microscopy AFM of (1) undoped ZnO,(2) ZnO with 3\% Al-doping concentration,(3) ZnO with 5\% Al,(4) ZnO with 10\% Al.

Fig. 6.  Morphological characteristics of undoped and Al-doped ZnO thin films.

Fig. 7.  Resistivity variation as function of the concentration of Al.

Table 1.   Structural analysis of elaborated ZnO thin films.

Table 2.   Topographical analysis of ZnO thin films.

Table 3.   Electrical characteristics given by Hall effect.

Table 4.   Comparison of the TCO figure of merit of the conventional undoped ZnO with the Al-doped ZnO thin film.

[1]
Aydemir S, Karakaya S. Effects of withdrawal speed on the structural and optical properties of sol-gel derived ZnO thin films. J Magn Magn Mater, 2015, 373:33 doi: 10.1016/j.jmmm.2014.01.077
[2]
Sun Guipeng, Yan Jinliang, Niu Peijiang, et al. Electronic structure and optical property of p-type Zn-doped SnO2 with Sn vacancy. Journal of Semiconductors 2016, 37(2):023005 doi: 10.1088/1674-4926/37/2/023005
[3]
Ozgur U, Alivov Y I, Liu C, et al. A comprehensive review of ZnO materials and devices. J Appl Phys, 2005, 98(4):041301 doi: 10.1063/1.1992666
[4]
Shewale P S, Yu Y S. Growth-temperature-dependent optical and acetone detection properties of ZnO thin films. Journal of Semiconductors, 2015, 36(7):073001 doi: 10.1088/1674-4926/36/7/073001
[5]
Benhaliliba M, Tiburcio-Silver A, Avila-Garcia A, et al. The sprayed ZnO films:nanostructures and physical parameters. Journal of Semiconductors, 2015, 36(8):083001 doi: 10.1088/1674-4926/36/8/083001
[6]
Suvaci E, Özer İ Ö. Processing of textured zinc oxide varistors via templated grain growth. J Eur Ceram Soc, 2005, 25:1663 doi: 10.1016/j.jeurceramsoc.2004.05.026
[7]
Liang S, Sheng H, Liu Y, et al. ZnO Schottky ultraviolet photodetectors. J Cryst Growth, 2001, 225:110 doi: 10.1016/S0022-0248(01)00830-2
[8]
Pan Z, Tian X, Hu J, et al. Investigation of optical and electronic properties in Al-Sn co-doped ZnO thin films. Mater Sci Semicond Process, 2013, 16:587 doi: 10.1016/j.mssp.2012.06.020
[9]
Qu X, Lu S, Jia D, et al. First-principles study of the electronic structure of Al and Sn co-doping ZnO system. Mater Sci Semicond Process, 2013, 16:1057 doi: 10.1016/j.mssp.2013.04.002
[10]
Tian X, Pan Z, Zhang H, et al. Growth and characterization of the Al-doped and Al-Sn co-doped ZnO nanostructures. Ceram Int, 2013, 39:6497 doi: 10.1016/j.ceramint.2013.01.081
[11]
Huang M C, Wang T H, Cheng S H, et al. The structure and photoelectrochemistry of Al, Ti co-doped zinc oxide thin films prepared by sol-gel dip-coating process. Nanosci Nanotechnol Lett, 2014, 6:210 doi: 10.1166/nnl.2014.1754
[12]
Oleynik N, Adam M, Krtschil A. MOVPE growth and characterization of ZnO properties for optoelectronic applications. J Cryst Growth, 2003, 248:14 doi: 10.1016/S0022-0248(02)01879-1
[13]
Caglar Y, Caglar M, Ilikan S. Microstructural, optical and electrical studies on sol-gel derived ZnO and ZnO:Al films. Curr Appl Phys, 2012, 12(8):963 http://cn.bing.com/academic/profile?id=2006989597&encoded=0&v=paper_preview&mkt=zh-cn
[14]
Xu Z Q, Deng H, Li Y, et al. Ultraviolet photoconductive detector based on Al doped ZnO films prepared by sol-gel method. Appl Surf Sci, 2006, 253:476 doi: 10.1016/j.apsusc.2005.12.113
[15]
Kuo S Y, Chen W C, Lai F I. et al. Effects of doping concentration and annealing temperature on properties of highly-oriented Aldoped ZnO films. J Cryst Growth, 2006, 287(1):78 doi: 10.1016/j.jcrysgro.2005.10.047
[16]
Benouis C E, Benhaliliba M, Juareze A S, et al. The effect of indium doping on structural, electrical conductivity, photoconductivity and density of states properties of ZnO films. Journal of Alloys and Compounds, 2010, 490:62 doi: 10.1016/j.jallcom.2009.10.098
[17]
Hsu L S, Yeh C S, Kuo C C, et al. Optical and transport properties of undoped and Al-, Ga-and In-doped ZnO thin films. J Optoelectron Adv Mater, 2005, 7(6):3039 http://joam.inoe.ro/arhiva/pdf7_6/Hsu.pdf
[18]
Caglar Y, Ilican S, Caglar M, et al. Effects of In, Al and Sn dopants on the structural and optical properties of ZnO thin films. Spectrochim Acta, 2007, 67:1113 doi: 10.1016/j.saa.2006.09.035
[19]
Lucio-Lopez M A, Luna-Arias M A, Maldonado A, et al. Doublelayer indium doped zinc oxide for silicon thin-film solar cell prepared by ultrasonic spray pyrolysis. Solar Energy Mater Solar Cells, 2006, 90:733 doi: 10.1016/j.solmat.2005.04.010
[20]
Ratheesh Kumar P M, SudhaKartha C, Vijayakumar K P. Doping of spray-pyrolyzed ZnO thin films through direct diffusion of indium:structural optical and electrical studies. J Appl Phys, 2012, 98:023509 http://cn.bing.com/academic/profile?id=2086104209&encoded=0&v=paper_preview&mkt=zh-cn
[21]
Xue S W, Zu X T, Zhou W L, et al. Effects of post-thermal annealing on the optical constants of ZnO thin film. Journal of Alloys and Compounds, 2008, 448:21 doi: 10.1016/j.jallcom.2006.10.076
[22]
Ghosh R, Paul G K, Basak D. Structural and optical characterization of high-quality ZnO. Materials Research Bulletin, 2005, 40:190
[23]
Arif A, Belahssen O, Gareh S, et al. Influence of precursor molarity on the optical properties of ZnO thin films. Journal of Semiconductors, 2015, 36(1):013001 doi: 10.1088/1674-4926/36/1/013001
[24]
Mahmood K, Amin N, Ali A, et al. Enhancement of phosphorssolubility in ZnO by thermal annealing. Journal of Semiconductors, 2015, 36(12):123001 doi: 10.1088/1674-4926/36/12/123001
[25]
Ghosh D S, Chena T L, Formica N, et al. High figure-of-merit Ag/Al:ZnO nano-thick transparent electrodes for indium-free flexible photovoltaics. Solar Energy Materials and Solar Cells, 2012, 107:338 doi: 10.1016/j.solmat.2012.07.009
[26]
Zhanchang P, Xinlong T, Guanghui H, et al. Investigation of optical and electronic properties in Al-Sn co-doped ZnO thin films. Materials Science in Semiconductor Processing, 2013, 587:592 http://cn.bing.com/academic/profile?id=2083150510&encoded=0&v=paper_preview&mkt=zh-cn
  • Search

    Advanced Search >>

    GET CITATION

    shu

    Export: BibTex EndNote

    Article Metrics

    Article views: 2863 Times PDF downloads: 63 Times Cited by: 0 Times

    History

    Received: 15 April 2016 Revised: 22 May 2016 Online: Published: 01 November 2016

    Catalog

      Email This Article

      User name:
      Email:*请输入正确邮箱
      Code:*验证码错误
      N. Boukhenoufa, R. Mahamdi, D. Rechem. Structural, optical, morphological and electrical properties of undoped and Al-doped ZnO thin films prepared using sol-gel dip coating process[J]. Journal of Semiconductors, 2016, 37(11): 113001. doi: 10.1088/1674-4926/37/11/113001 N. Boukhenoufa, R. Mahamdi, D. Rechem. Structural, optical, morphological and electrical properties of undoped and Al-doped ZnO thin films prepared using sol-gel dip coating process[J]. J. Semicond., 2016, 37(11): 113001. doi: 10.1088/1674-4926/37/11/113001.Export: BibTex EndNote
      Citation:
      N. Boukhenoufa, R. Mahamdi, D. Rechem. Structural, optical, morphological and electrical properties of undoped and Al-doped ZnO thin films prepared using sol-gel dip coating process[J]. Journal of Semiconductors, 2016, 37(11): 113001. doi: 10.1088/1674-4926/37/11/113001

      N. Boukhenoufa, R. Mahamdi, D. Rechem. Structural, optical, morphological and electrical properties of undoped and Al-doped ZnO thin films prepared using sol-gel dip coating process[J]. J. Semicond., 2016, 37(11): 113001. doi: 10.1088/1674-4926/37/11/113001.
      Export: BibTex EndNote

      Structural, optical, morphological and electrical properties of undoped and Al-doped ZnO thin films prepared using sol-gel dip coating process

      doi: 10.1088/1674-4926/37/11/113001
      More Information
      • Corresponding author: N.Boukhenoufa, boukhenoufanour@gmail.com;faycaldzdz@hotmail.com
      • Received Date: 2016-04-15
      • Revised Date: 2016-05-22
      • Published Date: 2016-11-01

      Catalog

        /

        DownLoad:  Full-Size Img  PowerPoint
        Return
        Return